发烟硫酸贮罐清洗安全技术

根据事故隐患分析 ,采取安全措施 ,成功地用中和法清洗发烟硫酸贮罐 ,并提出了贮罐的改进措施。     

沈阳市北部污水处理厂工艺设计的特点

详细介绍了污水处理厂的设计规模、SDAO污水处理工艺、各个单体构筑物的主要设计参数,SDAO工艺采用圆形曝气池,在工艺和结构设计上有所创新。污泥采用消化处理,污泥加热方式比较科学。     

基于生态槽实验的藻类生长参数确定

在太湖湖泊生态系统研究站的生态模拟槽中进行了藻类的动态模拟实验.取太湖原水至生态槽中,在温度、光照、营养盐变化条件下进行采样,观察藻类的变化情况.在生态槽实验基础上应用PHREEQC模型建立了藻类生长模型,模型中考虑了氮及磷营养盐的循环过程.利用生态模拟槽实验结果对太湖藻类生长模型的各参数进行了详细的率定验证,并应用最小二乘法确定最佳的一组参数,藻类及各种营养盐浓度的模拟值均能较好地拟合实验测量值.     

水解池-稳定塘工艺对难降解有机污染物的去除

色谱－质谱联机测定结果表明,水解池能将大分子难降解有机物转化为小分子物质,从而加速了污水在后续稳定塘中的降解。这使得新工艺比对照的传统初沉池－稳定塘工艺减少停留５０％,占地面积５０％以上。本文还研究了三氯甲烷,二氯乙烯,二氯乙烷和四氯乙烷和四氯化碳在新工艺中的去除情况,实验表明,水解池中存在还原脱卤过程,而挥发是稳定塘去除卤代烃的主要途径。     

搅拌槽液相吸附过程的数学模拟研究——粒内表面扩散控制

分别利用Langmuir、Freundlich和Fritz－Schlunder三种等温吸附平衡关系,对粒内表面扩散控制时的搅拌槽液相吸附动力学过程进行数学模拟研究,同时指出日本《化学工学便览》第四版和第五版中关于求取粒内表面扩散系数部分内容所存在的问题。若按上述《便览》中的公式或图去求粒内有效表面扩散系数Ds,则其平均误差将可能达到340％左右,这是因为铃木基之和河添帮太朗等人在利用“单点拟合法”确定有效表面扩散系数Ds时,错误地将无因次吸附时间等于1.0视为吸附平衡时间所致。文中还对《便览》中存在的上述问题提出了相应的修正意见     

高效生活污水处理装置--高性能合并处理净化槽

详细介绍了从日本引进的一体化生活污水处理装置--高性能合并处理净化槽的特点、运行机理和在日本的应用情况.     

Improved models of failure time for atmospheric tanks under the coupling effect of multiple pool fires

Fire accidents of chemical installations may cause domino effects in atmospheric tank farms, where a large amount of hazardous substances are stored or processed. Pool fire is a major form of fire accidents, and the thermal radiation from pool fire is the primary hazard of domino accidents. The coupling of multiple pool fires is a realistic and important accident phenomenon that enhances the propagation of domino accidents. However, previous research has mostly focused on the escalation of domino accidents induced by a single pool fire. To overcome the drawback, in this study, the failure of a storage tank under the coupling effect of multiple pool fires was studied in view of spatial and temporal synergistic process. The historical accident statistics indicated that the accident scenario of two-pool fires accounted for 30.6% in pool fires. The domino accident scenario involving three tanks is analyzed, and the typical layout of tanks is isosceles right triangle based on Chinese standard “GB50341-2014”. The thermal response and damage of a target tank heated by pool fires were numerically investigated. The volume of 500 m³, 3000 m³, 5000 m³ and 10000 m³ were selected. Flame temperature was obtained by FDS, and then was input onto the finite element model. The temperature field and stress field of target tanks were simulated by ABAQUS. The results showed that the temperature rise rate of the target tanks under multiple pool fires was higher than that under a single pool fire. The failure time of the tank under the coupling effect of multiple fires was lower than that under the superposition of multiple fires without the first stage. The stress and yield strength were compared to judge the failure of the target tank. The model of failure time for the tank under the coupling effect of pool fires was established. Through the verification, the deviation of this model is 4.02%, which is better than the deviation of 15.76% with Cozzani's model.     

The evolution of flame length for the oil tank fire with different top cover widths and lip heights

This study presents a quantitative analysis and interpretation of the variation in oil tank fire flame lengths for different oil tank sizes, top cover widths, and horizontal air flow velocities. The experimental results show that, at first, the flame length rises slowly with an increase in air flow speed. Then, once over a critical speed (0.6 m/s), the flame length decreases significantly with a further increase in air flow speed. Based on the characteristic length, a new dimensionless heat release rate is obtained, allowing the correlation between flame length, air flow speed, and dimensionless heat release rate to be calculated, which can be used to predict the flame length of an oil tank fire under different air flow speeds, lip heights, and cover widths.     

SBR法处理化粪池出水的工艺研究

采用经实验运行得到SBR工艺处理化粪池出水的合理的操作模式,能获得90%以上稳定的COD_(cr)去除率及更好的BOD_5去除效果,NH_3-N去除率大于75%,TN去除率大于45%.并考察了污泥浓度、泥龄、污泥负荷与处理效果的关系,以及闲置期对反应周期的影响.实验结果表明,SBR工艺对处理水质、水量负荷变化很大的化粪池出水,是一种理想的工艺选择.     

对一起汽车槽车装车过程中发生闪燃着火事件的分析

利用故障树分析(FTA)对汽车槽车装车过程中引起的闪燃着火事件进行了分析,针对中转油站存在的安全隐患提出整改措施.